The purpose of this action is to make changes to the Risk Management Program (RMP) rule in order to improve safety at facilities that use and distribute hazardous chemicals. Because major and other serious and concerning RMP accidents continue to occur, this final rule aims to better identify and further regulate risky facilities to prevent accidental releases before they can occur.

On March 11, 2024, the U.S. Environmental Protection Agency (EPA) published the much-anticipated Safer Communities by Chemical Accident Prevention Rule (SCCAP) Final Rule, an update to EPA’s Risk Management Program (RMP) 40 CFR Part 68, under the Clean Air Act Amendments of 1990 (CAA). This is the first substantial change to the rule since its inception in 1996.

The three-year HyTunnel CS project culminated in the report titled Deliverable D6.9, “Recommendations for inherently safer use of hydrogen vehicles in underground traffic systems.” The HyTunnel CS project aimed to perform pre-normative research for the safety of hydrogen-fueled vehicles traveling through tunnels or entering confined spaces. The main objective was to compare the relative risk of hydrogen vehicles entering underground traffic systems to existing fossil fuel-powered vehicles [1].

Several codes require excess flow valves in pipelines so that in the case of line rupture, the flow will be shut off.   In theory, this is a good idea, however, in practicality, it has many limitations.  The sizing and practical uses make the sizing difficult if sometimes impossible, depending on the design parameters.   

The adoption of hydrogen (H²) as a clean, zero-carbon renewable energy source promises a global revolution, eliminating harmful emissions responsible for climate change. This white paper explores the opportunities and implications of an emerging hydrogen society. MSA Safety examines workplace safety risks and challenges posed when producing, handling, transporting, and storing alongside suggested best practices, safety measures, and detection technologies.

Natural gas was first used as a vehicle fuel as far back as the 1930s. The first natural gas vehicles, which ran on uncompressed natural gas, were called “gas bag” vehicles and were used to combat gasoline shortages during World War I [1]. During and after World War II, compressed natural gas (CNG) vehicles using fuel tanks mounted on the roof gained popularity in France and Italy [2]. Today, there are more than 24 million CNG vehicles in service worldwide, including CNG buses that continue the early tradition of mounting fuel tanks on the roof.  

The HSP has reviewed many safety plans for gaseous hydrogen. An emerging trend is the use of liquid (cryogenic) hydrogen in the commercial market, potentially near residential areas, for fueling hydrogen fuel cell vehicles. Finding a “qualified” person to determine liquid hydrogen code compliance is difficult, and the skills necessary of such an individual are not well defined in the codes and standards.

In developing a 70 megapascal (MPa) fueling infrastructure, it is critical to ensure that a vehicle equipped with a lower service pressure fuel tank is never filled from a 70 MPa fueling source. Filling of a lower service pressure vehicle at a 70 MPa fueling source is likely to result in a catastrophic event with severe injuries or fatalities. The Hydrogen Safety Panel recommends that DOE undertake a two‐step process to address this issue.